Differential Fluid
Differential Fluid
What type and weight fluids are being used in front and rear differentials, 435/445 transmissions, and transfer cases? The manual says, 140 weight or 90 weight. What would be the difference in performance between 140 and 90? Also in my old FFPW, I used 50 weight oil in the trans and transfer case and 90 wt in the diffs. Are the multi 85W-140W a good choice?
John
John
1970 W200
318, NP 445
Factory LU-2 winch
A/C, HD Gauges
318, NP 445
Factory LU-2 winch
A/C, HD Gauges
- Trailmaster
- Sweptline.ORG Member
- Posts: 196
- Joined: Sun Oct 04, 2009 1:21 am
- City: Ellicott
- State: CO
- Location: Ellicott, Colorado, USA
Re: Differential Fluid
I always used 80W90 in the gear cases on my older stuff, never had any problems with it.
70 D200 Camper Special 383/727/4:10/AC/PS/PB
74 Trailduster 318/727/NP203/3.55/PS/PB
75 Duster 225/904/PS
76 D300 Adventurer Sport 440/727/4:10/AC/PS/PB/Cruise
74 Trailduster 318/727/NP203/3.55/PS/PB
75 Duster 225/904/PS
76 D300 Adventurer Sport 440/727/4:10/AC/PS/PB/Cruise
Re: Differential Fluid
JB, I read about oil a while back but don't remember all the details The different weights of oils are related to the ambient temperature on start up. The lighter weight oil carbons lube in cold weather while the heavier lubes better when it warms up. This is why a 10-40 motor oil is suppose to be so much better than strait 30 wt. The 10 is lubing on fire up and the 40 is doing it's job at operating temp.
Since you live down in Florida you could run the 140 wt. but if you don't have a bunch of oil leaks the 90 wt. will be less drag and get better fuel mileage.
Since you live down in Florida you could run the 140 wt. but if you don't have a bunch of oil leaks the 90 wt. will be less drag and get better fuel mileage.
- nfury8
- Sweptline.ORG Pioneer
- Posts: 2443
- Joined: Wed Dec 31, 1969 6:00 pm
- City: KC, MO
- Location: Kansas City
- Contact:
Re: Differential Fluid
Unless you really work the truck, I would stick with the 80-90 or a straight 90w if available.
71 D100 Adventurer SE - PowerWagon conversion
70 W200 CrewCab - Urban Assault Kiddie Hauler
69 Plymouth Fury III Convertible - Pro Touring Machine
69 Plymouth Fury III Convertible - Beater, Hiding in a cave
70 W200 CrewCab - Urban Assault Kiddie Hauler
69 Plymouth Fury III Convertible - Pro Touring Machine
69 Plymouth Fury III Convertible - Beater, Hiding in a cave
- hmaynord
- Sweptline.ORG Member
- Posts: 237
- Joined: Sat Aug 12, 2017 11:49 pm
- City: fairhope
- State: AL
- Location: lower Alabama
Re: Differential Fluid
probably been in there for decades. thinking about about evacuating and replacing.
any suggestions?
any suggestions?
harris
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
Re: Differential Fluid
Drive it until trans, rear etc are warm; drain it and replace.hmaynord wrote:probably been in there for decades. thinking about about evacuating and replacing.
any suggestions?
1970 W200
318, NP 445
Factory LU-2 winch
A/C, HD Gauges
318, NP 445
Factory LU-2 winch
A/C, HD Gauges
- hmaynord
- Sweptline.ORG Member
- Posts: 237
- Joined: Sat Aug 12, 2017 11:49 pm
- City: fairhope
- State: AL
- Location: lower Alabama
Re: Differential Fluid
right. I always get my oil up to operating temp before i change it.
never thought about doing the same for diff.
never thought about doing the same for diff.
harris
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
- hmaynord
- Sweptline.ORG Member
- Posts: 237
- Joined: Sat Aug 12, 2017 11:49 pm
- City: fairhope
- State: AL
- Location: lower Alabama
Re: Differential Fluid
for my chrysler RA36 rear axle, 66 SM states:
delivered from factory with 90W gear oil,
can use 90W as low as -10 F, and
above 90 F, use 140W.
down here, driving it below 45 F will be rare, but there will be a lot above 80 F, some above 90 F, and rarely above 100 F.
I'm going to leave the same fluid in year round.
maybe I can find straight 90W, but most is 80W-90.
should I use 80W-90 or 140?
half and half (never done that)?
does it matter that I have had over the decades a tendency for the right rear axle seal to leak into the brake drum?
delivered from factory with 90W gear oil,
can use 90W as low as -10 F, and
above 90 F, use 140W.
down here, driving it below 45 F will be rare, but there will be a lot above 80 F, some above 90 F, and rarely above 100 F.
I'm going to leave the same fluid in year round.
maybe I can find straight 90W, but most is 80W-90.
should I use 80W-90 or 140?
half and half (never done that)?
does it matter that I have had over the decades a tendency for the right rear axle seal to leak into the brake drum?
harris
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
- hmaynord
- Sweptline.ORG Member
- Posts: 237
- Joined: Sat Aug 12, 2017 11:49 pm
- City: fairhope
- State: AL
- Location: lower Alabama
Re: Differential Fluid
forget it. found the answer.
as some of you probably already know, they make an 85W-140.
as some of you probably already know, they make an 85W-140.
harris
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
- marklein
- Sweptline.ORG Member
- Posts: 607
- Joined: Sun Nov 11, 2012 9:55 am
- City: Red Deer
- State: Foreign
Re: Differential Fluid
Do not put synthetic in the trans. Will not be able to shift it. Too slippery for those aluminum blockers. Use heavier diff oils in hot weather and thinner in cold weather.
- hmaynord
- Sweptline.ORG Member
- Posts: 237
- Joined: Sat Aug 12, 2017 11:49 pm
- City: fairhope
- State: AL
- Location: lower Alabama
Re: Differential Fluid
right. this is not synthetic. just the good old natural stuff.
as you say, manual says to change it according to expected temp.
like any other multi-viscosity oil, this 85W-140 should satisfy those requirements.
as you say, manual says to change it according to expected temp.
like any other multi-viscosity oil, this 85W-140 should satisfy those requirements.
harris
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71
late 65 (titled as 66) D100 SWB 225-1, 3 speed, 3.91
driving it since 12/03/71